Part 8 (2/2)
[Spanish prejudice against bathing.] Our departure hence was delayed by festivities and sudden showers for about two days, after which the spirited horses of the alcalde carried us within an hour on a level road north-west, to Talisay, and in another hour to Indang, where a bath and breakfast were ready. Up to this time I had never seen a bath-room in the house of a Spaniard; whereas with the Northern Europeans it is never wanting. The Spaniards appear to regard the bath as a species of medicine, to be used only with caution; many, even to the present day, look upon it as an inst.i.tution not quite Christian. At the time of the Inquisition frequent bathing, it is known, was a characteristic of the Moors, and certainly was not wholly free from danger. In Manila, only those who live near the Pasig are the exceptions to the rule; and there the good or bad practice prevails of whole families bathing, in the company of their friends, in the open air.
[An unfortified fort.] The road ends at Indang. In two boats we went down the river till stopped by a bar, and there at a well-supplied table prepared for us by the kindness of the alcalde we awaited the horses which were being brought thither along a bad road by our servants. In the waste of Barre a tower, surrounded by two or three fishermen's huts and as many camarines, has been erected against the Moros, who, untempted by the same, seldom go so far westward, for it consists only of an open hut covered with palm-leaves--a kind of parasol--supported on stakes as thick as one's arm and fifteen feet high; and the two cannons belonging to it ought, for security, to be buried. We followed the sea-sh.o.r.e, which is composed of silicious sand, and covered with a carpet of creeping sh.o.r.e plants in full bloom. On the edge of the wood, to the left, were many flowering shrubs and panda.n.u.s with large scarlet-red flowers. After an hour we crossed the river Longos in a ferry, and soon came to the spur of a crystalline chain of mountains, which barred our road and extended itself into the sea as Point Longos. The horses climbed it with difficulty, and we found the stream on the other side already risen so high that we rode knee-deep in the water. After sunset we crossed singly, with great loss of time, in a miserable ferry-boat, over the broad mouth of the Pulundaga, where a pleasant road through a forest led us, in fifteen minutes, over the mountain-spur, Malanguit, which again projected itself right across our path into the sea, to the mouth of the Paracale. The long bridge here was so rotten that we were obliged to lead the horses over at wide intervals apart; and on the further side lies the place called Paracale, from which my companions continued their journey across Mauban to Manila.
[Red lead.] Paracale and Mambulao are two localities well known to all mineralogists, from the red lead ore occurring there. On the following morning I returned to Longos; which consists of only a few miserable huts inhabited by gold-washers, who go about almost naked, probably because they are laboring during the greater part of the day in the water; but they are also very poor.
[Gold mining.] The soil is composed of rubbish, decomposed fragments of crystalline rock, rich in broken pieces of quartz. The workmen make holes in the ground two and one-half feet long, two and one-half broad, and to thirty feet deep. At three feet below the surface the rock is generally found to contain gold, the value increasing down to eighteen feet of depth, and then again diminis.h.i.+ng, though these proportions are very uncertain, and there is much fruitless search. The rock is carried out of the holes in baskets, on ladders of bamboo, and the water in small pails; but in the rainy season the holes cannot possibly be kept free from water, as they are situated on the slope of the mountain, and are filled quicker than they can be emptied. The want of apparatus for discharging water also accounts for the fact that the pits are not dug deeper.
[A primitive rock breaker.] The breaking of the auriferous rock is effected with two stones; of which one serves as anvil, and the other as hammer. The former, which is slightly hollowed in the center, is laid flat upon the ground; and the latter, four by eight by eight inches in dimensions, and therefore of about twenty-five pounds weight, is made fast with rattan to the top of a slender young tree, which lies in a sloping position in a fork, and at its opposite end is firmly fixed in the ground. The workman with a jerk forces the stone that serves for hammer down upon the auriferous rock, and allows it to be again carried upwards by the elasticity of the young tree.
[An arrastre.] The crus.h.i.+ng of the broken rock is effected with an apparatus equally crude. A thick stake rises from the center of a circular support of rough-hewn stones (which is enclosed in a circle of exactly similar stones) having an iron pin at its top, to which a tree, bent horizontally in the middle, and downwards at the two ends, is fixed. Being set in motion by two carabaos attached in front, it drags several heavy stones, which are bound firmly to it with rattans, round the circle, and in this manner crushes the broken rock, which has been previously mixed with water, to a fine mud. The same apparatus is employed by the Mexican gold-washers, under the name of Rastra. [Gold-was.h.i.+ng.] The was.h.i.+ng-out of the mud is done by women. They kneel before a small wooden gutter filled with water up to the brim, and provided with boards, sloping downwards, in front of the s.p.a.ce a.s.signed to each woman; the gutter being cut out at these places in a corresponding manner, so that a very slender stream of water flows evenly across its whole breadth downwards over the board. With her hand the work-woman distributes the auriferous mud over the board, which, at the lower edge, is provided with a cross-piece; and, when the light sand is washed away, there remains a stratum consisting chiefly of iron, flint, and ore, which is taken up from time to time with a flat piece of board, and laid on one side; and at the end of the day's work, it is washed out in a flat wooden dish (batea), and, for the last time, in a coco-sh.e.l.l; when, if they are lucky, a fine yellow dust shows itself on the edge. [129] During the last was.h.i.+ng the slimy juice of the Gogo is added to the water, the fine heavy sand remaining suspended therein for a longer time than in pure water, and thus being more easily separated from the gold-dust. [130]
[The clean-up.] It is further to be mentioned that the refuse from the pits is washed at the upper end of the water-gutter, so that the sand adhering to the stones intended for pounding may deposit its gold in the gutter or on the was.h.i.+ng-board. In order to melt the gold thus obtained into a lump, in which form it is bought by the dealers, it is poured into a small heart-sh.e.l.l (cardium), and, after being covered with a handful of charcoal, placed in a potsherd; when a woman blows through a narrow bamboo-cane on the kindled coals, and in one minute the work is completed. [131]
The result of many inquiries shows the profit per head to average not more than one and one-half reals daily. Further to the south-west from here, on the mountain Malaguit, are seen the ruins of a Spanish mining company; a heap of rubbish, a pit fifty feet deep, a large house fallen to ruin, and a stream-work four feet broad and six feet high. The mountain consists of gneiss much decomposed, with quartz veins in the stream-work, with the exception of the bands of quartz, which are of almost pure clay earth with sand.
[Edible bird's nests.] On the sides hung some edible nests of the salangane, but not of the same kind as those found in the caverns on the south coast of Java. These, which are of much less value than the latter, are only occasionally collected by the Chinese dealers, who reckon them nominally at five cents each. We also found a few of the nest-building birds (Collocalia troglodytes, Gray). [132]
[Abandoned workings.] Around lay so large a number of workings, and there were so many little abandoned pits, wholly or half fallen to ruin, and more or less grown over, that it was necessary to step between with great caution. Some of them were still being worked after the mode followed at Longos, but with a few slight improvements. The pits are twice as large as those excavated there, and the rock is lifted, up by a pulley to a cylindrical framework of bamboo, which is worked by the feet of a lad who sits on a bank higher up.
[Lead and mica.] Ten minutes north of the village of Malaguit is a mountain in which lead-glance and red lead have been obtained; the rock consisting of micaceous gneiss much decomposed. There is a stream-work over one hundred feet in length. The rock appears to have been very poor.
The highly prized red-lead ores have been found on the top of this same hill, N. 30 W. from the village. The quarry was fallen to ruin and flooded with rain, so that only a shallow hollow in the ground remained visible; and after a long search amongst the bushes growing there a few small fragments were found, on which [Chrome-lead ore.] chrome-lead ore was still clearly to be recognized. Captain Sabino, the former governor of Paracale, a well-informed Filipino, who, at the suggestion of the alcalde, accompanied me, had for some years caused excavations to be carried on, in order to find specimens for a speculator who had in view the establishment of a new mining company in Spain; but the specimens which were found had not been removed, as speculation in mines in the Philippines had, in the interval, fallen into discredit on the Exchange of Madrid; and as yet only a little box full of sand, out of a few small drusy cavities, has been fixed upon and pounded, to be sold as variegated writing-sand, after being carefully sifted.
[A pretty fan-palm.] A peculiarly beautiful fan-palm grows on this hill. Its stem is from thirty to forty feet high, cylindrical and dark-brown, with white rings a quarter of an inch broad at distances of four inches, and, at similar intervals, crown-shaped bands of thorns two inches long. Near the crown-leaf the stem pa.s.ses into the richest brown of burnt sienna.
[Rooming in a powder-magazine.] Notwithstanding a very bad road, a pleasant ride carried us from Paracale to the sea-sh.o.r.e, and, through a beautiful wood, to Mambulao, which lies W. by N. I alighted at the tribunal, and took up my lodgings in the room where the ammunition was kept, as being the only one that could be locked. For greater security, the powder was stored in a corner and covered with carabao-hide; but such were my arrangements that my servant carried about a burning tallow light, and his a.s.sistant a torch in the hand. When I visited the Filipino priest, I was received in a friendly manner by a young girl who, when I offered my hand, thanked me with a bow, saying, ”Tengo las sarnas” (”I have the itch”). The malady, which is very common in the Philippines, appears to have its focus in this locality.
[Gneiss and crystalline rock.] A quarter of a league N.N.E. we came upon the ruins of another mining undertaking, the Ancla de Oro. Shaft and water-cutting had fallen in, and were thickly grown over; and only a few of the considerable buildings were still standing; and even those were ready to fall. In a circle some natives were busily employed, in their manner, collecting grains of gold. The rock is gneiss, weathered so much that it cannot be recognized; and at a thousand paces on the other side is a similar one, clearly crystalline.
[Hornblende and hornblende slate.] Half a league N. by E. from Mambulao is the lead-mountain of Dinianan. Here also all the works were fallen in, choked with mud and grown over. Only after a long search were a few fragments found with traces of red-lead ore. This mountain consists of hornblende rock; in one place, of hornblende slate, with very beautiful large crystals.
[Copper.] A league and a half S. from Mambulao a shallow hollow in the ground marks the site of an old copper-mine, which must have been eighty-four feet deep. Copper ores are found in several places in Luzon; and specimens of solid copper were obtained by me at the Bay of Luyang, N. of the Ensenada de Patag, in Caramuan.
[Unsuccessful copper-mining.] Very considerable beds of copper ore occur in Mancayan, in the district of Lepanto, and in the central mountain-range of Luzon between Cagayan and Ilocos, which have been worked by a mining company in Manila since 1850; but the operations seem to have been most unsuccessful. In 1867 the society expended a considerable capital in the erection of smelting furnaces and hydraulic machinery; but until a very recent date, owing to local difficulties, particularly the want of roads, it has not produced any copper. [133]
[Paying minus dividends.] In 1869 I heard, in London, that the undertaking had been given up. According to my latest information, however, it is certainly in progress; but the management have never, I believe, secured a dividend. The statement of 1872, in fact, shows a loss, or, as the Spaniards elegantly say, a dividendo pasivo.
[Igorot-mining successful.] What Europeans yet appear unable to accomplish, the wild Igorots, who inhabit that trackless range of mountains, have carried on successfully for centuries, and to a proportionally larger extent; and this is the more remarkable as the metal in that district occurs only in the form of flints, which even in Europe can be made profitable only by particular management, and not without expense.
[Long-established and considerable.] The copper introduced into commerce by the Igorots from 1840 to 1855, partly in a raw state, partly manufactured, is estimated at three hundred piculs yearly. The extent of their excavations, and the large existing ma.s.ses of slag, also indicate the activity of their operations for a long period of time.
[Copper kettles attributed to Negritos.] In the Ethnographical Museum at Berlin is a copper kettle made by those wild tribes. Meyer, who brought it, states that it was made by the Negritos in the interior of the island, and certainly with hammers of porphyry, as they have no iron; and that he further found, in the collection of the Captain General of the Philippines, a large shallow kettle of three and one-half feet in diameter, which had been bought for only three dollars; whence it may be inferred that, in the interior of the island, the copper occurs in large ma.s.ses, and probably solid; for how could those rude, uncultivated negritos understand the art of smelting copper?
[Copper-working a pre-Spanish art.] The locality of these rich quarries was still unknown to the Governor, although the copper implements brought thence had, according to an official statement of his in 1833, been in use in Manila over two centuries. It is now known that the copper-smiths are not Negritos but Igorots; and there can be no question that they practiced this art, and the still more difficult one of obtaining copper from flint, for a long period perhaps previous to the arrival of the Spaniards. They may possibly have learnt them from the Chinese or j.a.panese. The chief engineer, Santos [134], and many others with him, are of opinion that this race is descended from the Chinese or j.a.panese, from whom he insists that it acquired not only its features (several travellers mention the obliquely placed eyes of the Igorots), its idols, and some of its customs, but also the art of working in copper. At all events, the fact that a wild people, living isolated in the mountains, should have made such progress in the science of smelting, is of so great interest that a description of their procedure by Santos (essentially only a repet.i.tion of an earlier account by Hernandez, in the Revista Minera, i. 112) will certainly be acceptable.
[The Igorots' Method.] The present mining district acquired by the society mentioned, the Sociedad Minero-metalurgica Cantabrofilipina de Mancayan, was divided amongst the Igorots into larger or smaller parcels strictly according to the number of the population of the adjacent villages, whose boundaries were jealously watched; and the possessions of each separate village were again divided between certain families; whence it is that those mountain districts exhibit, at the present day, the appearance of a honeycomb. To obtain the ore, they made cavities, in which they lighted fires in suitable spots, for the purpose of breaking the rock into pieces by means of the elasticity of the heated water contained in the crevices, with the additional a.s.sistance of iron implements. The first breaking-up of the ore was done in the stream-work itself, and the dead heaps lay piled up on the ground, so that, in subsequent fires, the flame of the pieces of wood always reached the summit; and by reason of the quality of the rock, and the imperfection of the mode of procedure, very considerable down-falls frequently occurred. The ores were divided into rich and quartziferous; the former not being again melted, but the latter being subjected to a powerful and persistent roasting, during which, after a part of the sulphur, antimony, and a.r.s.enic had been exhaled, a kind of distillation of sulphate of copper and sulphate of iron took place, which appeared as ”stone,” or in b.a.l.l.s on the surface of the quartz, and could be easily detached. [135]
[The Smelter.] The furnace or smelting apparatus consisted of a round hollow in clayey gound, thirty centimeters in diameter and fifteen deep; with which was connected a conical funnel of fire-proof stone, inclined at an angle of 30, carrying up two bamboo-canes, which were fitted into the lower ends of two notched pine-stems; in these two slips, covered all over with dry gra.s.s or feathers, moved alternately up and down, and produced the current required for the smelting.
<script>